close

Вход

Забыли?

вход по аккаунту

?

Isocyanatoquinones.

код для вставкиСкачать
Experimental:
The a-aminoheterocycle (0.1 mol) is dissolved in anhydrous benzene or toluene and dropped into a boiling mixture
of oxalyl chloride (0.4-0.5 mol) and anhydrous benzene or
toluene (1-2 mol). The whole is boiled under reflux until
evolution of gas is completed ( 2 4 h). After filtration
(crystalline precipitates that are sometimes formed consist of the bisoxamides) and removal of solvent by distillation, the residue is distilled in a vacuum.
formation of the tritylated s-triazinamines, e.g., (7), m. p.
191-193°C.
c1
(7)
Received: March 11,1971 [ Z 391a IE]
German version: Angew. Chem. 83,406 (1971)
[l] U . 0. Gizycki and G . Oertel, Angew. Chem. 80, 363 (1968); Angew
Chem. internat. Edit. 7, 381 (1968).
Isocyanato-s-triazines
By Ulrich von Gizycki"'
Only one isocyanato-s-triazine, namely the 2,4-dichloro-6isocyanato derivative ( I ) , has previously been isolated,
and that from tetrameric cyanogen chloride by a route that
cannot be generalized"].
We have found that mono- and di-isocyanato derivatives
ofs-triazinecan be readily prepared in good yield by reaction
of the appropriate s-triazinamine with oxalyl chloride.
Experimental:
Finely powdered s-triazinamine (0.1 mol) is suspended in a
mixture of oxalyl chloride (0.3-0.5 mol per amino group)
and anhydrous toluene or chlorobenzene (1-2 mol) [but
distilled thiophane dioxide for ( 2 ) ] , and the mixture is
boiled under reflux until evolution of gas is complete
(7-8 h). After filtration and removal of solvent by distillation, the residue is distilled in a vacuum.
Received: March 11, 1971 [Z 391b IE]
German version: Angew. Chem. 83,407(1971)
[I] X Kodoma and 'Z Sekiba, J. SOC.Org. Syn. Chem., Japan 21, 888
(1963).
Isocyanatoquinones
By Ulrich von Gizycki'']
Quinones carrying an isocyanato substituent in the quinonoid ring have so far been unknown. We now report syntheses of two representatives of this new class of compound.
The isocyanato derivatives (1)-(6) are colorless solids or
liquids that distil without decomposition and are highly
reactive (Table 1). In their IR spectrum the NCO band lies
at 2250 cm- '. The reaction proceeds better the more
electronegative is the substituent R.
When a mixture of finely powdered 2,5-diamino-3,6-dichIoro-l,4-benzoquinone (100g), oxalyl chloride (400g),
anhydrous butyl acetate (200 ml), and anhydrous chlorobenzene (550 ml) is boiled under reflux until gas evolution
ceases (-36 h), then, on cooling, red needles of 2,5-dichloro-3,6-diisocyanato-1,4-benzoquinone
( I ) (about 50 g)
separate.
Table 1. Properties of the isocyanates ( I ) to (6)
Isocyanate
B. p. (T i t o r r )
At room temp.
Yield (%)
(1)
105-106/1&12
147.51760
13413510 2-0.3
84-8510.2
126-12710.9
152-15310.3
Solid
Liquid
Solid
Solid
Liquid
Solid
93
70
70
85
84
75
(2)
(3)
14)
(5)
(6 1
Table 2. Melting points of the urethanes prepared from the isocyanates
(1) to (6).
Isocyanate
Alcohol
M. p. ("C)
(1)
1,3-Dichloro-2-propanol
Phenol
1-Butanol
Phenol
1,3-Dichloro-2-propanol
Phenol
124-125
136-137
105-108
161-163
11&114 [a]
Dec. from 21 5
(2)
(3)
(4)
(5)
(6)
M. p. of ( I ) : 259-260°C. IR: NCO band at 2205 cm- ',
CO at 1665 and 1675 cm- '. Bis(ethy1urethane): orange
needles, m. p. 220-221 "C.
(2) was
Yellow 2-chloro-3-isocyanato-1,4-naphthoquinone
obtained analogously in 75% yield from 2-amino-3-chloro1,4-naphthoquinone (50 g) and oxalyl chloride (200 g) in
anhydrous o-dichlorobenzene.
"
[a] Contains solvent (CCI,).
The isocyanates ( I ) to (6) react smoothly with alcohols
or phenols, yielding urethanes or diurethanes (Table 2).
Reaction with triphenylmethanol at 0-20°C affords the
urethanes which at higher temperatures lose CO, with
[*] Dr. U. v. Gizycki
Wissenschaftliches Hauptlaboratorium,
Farbenfabriken Bayer AG
509 Leverkusen (Germany)
Angew. Chem. internat. Edit. 1 Vol. 10 (19711
(1)
0
(2)
The isocyanate (2) crystallizes after filtration and concentration of the solution to one-third of its volume.
',
M. p. of (2) : 140- 142"C. IR : NCO band at 2200 cmCO at 1670cm-'. Ethylurethane: yellow needles, m. p.
135-136"C.
Received: March 11,1971 [Z 391c IE]
German version: Angew. Chem. 83, 408(1971)
1 No. 6
403
Документ
Категория
Без категории
Просмотров
1
Размер файла
107 Кб
Теги
isocyanatoquinones
1/--страниц
Пожаловаться на содержимое документа